The Cook and Housekeeper's Complete and Universal Dictionary; Including a System of Modern Cookery, in all Its Various Branches, Adapted to the Use of Private Families. Eaton Mary
or a larger quantity with a machine of proportionate dimensions, in the same space of time. The process is so simple, that it may be comprehended by any person of ordinary capacity, and once seeing the operation performed will be sufficient. In the common mode of brewing, the principal difficulty consists in ascertaining the degrees of heat necessary to the production of good beer, without the use of a thermometer; but in the use of this machine, this difficulty is completely obviated. – The machine complete is represented by figure A; and B, C, D, E, F, represent its several parts. B is the bottom, made of strong sheet-iron, standing upon three legs. The hollow part of it contains the fire, put in at a door, the latch of which appears in front. The tube which projects upwards, is a stove pipe to carry off the smoke; and the circular pan that is seen between the legs, is a receptacle for the ashes or cinders that fall down through the grate above. C is a sheet-iron vessel, tinned on the inside, the bottom of which fits into the top of B; and the cock in C is to let off the wort, as will be seen hereafter. D is the lid of this vessel. E is made of sheet-iron, tinned inside and out, and full of holes to act as a strainer. It is to hold the malt first, and the hops afterwards; it goes into C, as may be seen in figure A. In the middle of E is a round space, F, made of the same metal, and rising up from the bottom, having itself no bottom. It has holes in it all the way up, like the outer surface of E. – In preparing for brewing, the machine is put together as in A, except placing on the lid. The first thing is to put the malt, coarsely ground, into E, and no part into F, or into the circular space between C and E; otherwise E cannot act as a strainer, when the liquor is drawn off; and in this consists its principal use. Having put in the malt, then add the water which of course flows into any part of the vessel C. Stir the malt well with a stick, or with something that will separate it completely, so that no adhesion may be formed by the flour of the malt. This is very apt to be the case in the common mode of brewing, when water is poured hot upon the malt; but here the water is applied in a cold state, so that there is little trouble in separating the malt completely in the water. If the small machine be used, which is adapted to a bushel of malt, and the beer is to be fully equal in strength to London porter, then eighteen gallons to the bushel may be considered as the general estimate; and for this purpose the first mash is to receive twelve gallons of cold soft water, which will produce nine gallons of wort. Having stirred the malt very carefully, light the fire under it, and get the liquor quickly to 170 or 180 degrees of heat. This may be ascertained by lifting off the lid, and dipping the thermometer from time to time into the centre F, and keeping it there a minute to give the quicksilver time to rise. While the mash is coming to this heat, stir the malt well three or four times. When the liquor has acquired its proper heat, put out the fire, and cover the whole of the machine with sacks, or something that will exclude the external air. In this state the mash remains for two hours: the cock is then turned, and nine gallons of wort will be drained off. Put the wort into a tub of some sort, and keep it warm. Then put into the machine twelve gallons more of water, rekindle the fire, and bring the heat to 170 degrees as soon as possible; when this is done, extinguish the fire, and let the mash now stand an hour. Draw off the second wort; and if only one sort of beer is wanted, add it to the first quantity. Now take out the grains, lift out E, clean it well, and also the inside of C. Replace E, put the hops into it, and the whole of the wort into the machine. Cover it with the lid, light the fire a third time, and bring the liquor to a boil as soon as possible. Let it boil a full hour with the lid off, and boil briskly all the time. The use of the centre F will now appear; for the machine being nearly full to the brim, the bubbling takes place in the centre F only, where there are no hops. There is a great boiling over in this centre, but the liquor sent up falls into E, and so there is no boiling over of C. When the full hour of brisk boiling has expired, put out the fire, draw off the liquor, leaving the hops of course in E. The liquor is now to go into shallow coolers; and when the heat is reduced to 70 degrees, take out about a gallon of the liquor, and mix it with half a pint of good yeast. Distribute it equally among the different parcels of wort, afterwards mix the whole together, and leave the liquor till it comes down to about sixty degrees of heat. The next removal is into the tun-tub, in which capacity C, without the addition of E, will serve very well. While the liquor is cooling, remove the spent hops from E, the stove pipe from B, the ash-receiver from the bottom. The machine remaining now as a tun-tub, draw off the liquor as soon as it is down to 60 degrees; or take it out of the coolers, pour it into the tun-tub, and put on the lid. If the weather be very cold, or the tun-tub be in a cold place, cover it with something to keep it warm. Here the fermentation takes place, sometimes sooner and sometimes later; but it generally shows itself by a head beginning to rise in about eight or ten hours; and at the end of eight and forty hours the head assumes a brownish appearance, and is covered with yeast instead of froth. The beer is then to be tunned into well-seasoned casks, sweet and sound, or all the expense and labour will be lost. The cask being fixed on the stand in the cellar, and the beer ready, skim off the yeast, and keep it in a deep earthen vessel. Draw off the beer into a pail, and with the help of a wooden funnel fill the cask quite full. The beer will now begin to ferment again, and must be allowed to discharge itself from the bung-hole. When the working has ceased, the cask is again filled up with the surplus beer; and a handful of fresh hops being added, the bung is finally closed down. If the whole process has been properly attended to, such a cask of beer will be clear in a week; and as soon as clear it may be tapped. Small beer may be tapped in less time. On a larger scale, or with casks of a smaller size, two sorts may be made, ale and small beer, taking the first wort for the former, and the second for the latter. – The advantages attending the Patent Machine are very obvious; for though the process appears to be minute, it is easily conducted, and but little time is required for the purpose. In the common method of brewing, the water must be carried from the copper to the mash-tub, while the machine serves for both purposes at once. With the common utensils the process is necessarily much slower, and the fuel consumed is nearly ten times as much; but the great convenience of all is the little room required and the place of brewing. In the common way there is wanted a copper fixed in brick-work, and for a family of any considerable size a brewhouse is indispensable. On the contrary, the machine is set up opposite any fire place, and the pipe enters the chimney, or is put into the fire place. There is no boiling over, no slopping about; and the operation may be performed upon a boarded floor, as well as upon a brick or stone floor. If there be no fire place in the room, the pipe can be projected through an opening in the window, or through the outside of any sort of building, not liable to suffer from the heat of the pipe. Even a garden walk, a court, or open field will answer the purpose, provided there be no rain, and the mash-tub be kept sufficiently warm. When the brewing is finished, the machine should be well scalded, rubbed dry, and kept in a dry place. The two coolers, G G, placed on different casks, have no necessary connection with the machine. They are made of wood or cast-iron, of a size to fit one within another to save room. The Patent Machine is sold by Messrs. Needham and Co. 202, Piccadilly, London. The price of one for brewing a bushel of malt is £8, for two bushels £13, for three £18, for four £24, for five £30, and for six £33. If the article be thought expensive, a few neighbouring families might unite in the purchase, and the money would very soon be more than saved in the economy of brewing.
BRIDE CAKE. Mix together a pound of dried flour, two drams of powdered mace, and a quarter of a pound of powdered loaf sugar. Add a quarter of a pint of cream, and half a pound of melted butter; a quarter of a pint of yeast, five eggs, with half of the whites beaten up with the yolks, and a gill of rose water. Having warmed the butter and cream, mix them together, and set the whole to rise before the fire. Pick and clean half a pound of currants, put them in warm and well dried.
BRIGHT BARS of polished stoves, may be restored to their proper lustre, by rubbing them well with some of the following mixture on a piece of broad-cloth. Boil slowly one pound of soft soap in two quarts of water, till reduced to one. Of this jelly take three or four spoonfuls, and mix it to a consistence with the addition of emery. When the black is removed, wipe them clean, and polish with glass, not sand-paper.
BRISKET OF BEEF, if intended to be stewed, should have that part of it put into a stewpot which has the hard fat upon it, with a small quantity of water. Let it boil up, and skim it well; then add carrots, turnips, onions, celery, and a few pepper corns. Stew it till it is quite tender; then take out the fat bones, and remove all the fat from the soup. Either serve that and the meat in a tureen, or the soup alone, and the meat on a dish, garnished with vegetables. The following sauce with the beef, will be found to be very excellent. –