THE MYSTERIOUS ISLAND. Jules Verne
the next day. Supper was prepared, a good fire blazed before the hut, the roast turned, and at eight o’clock, while one of the settlers watched to keep up the fire, in case any wild beasts should prowl in the neighborhood, the others slept soundly.
The next day, the 21st of April, Cyrus Harding accompanied by Herbert, went to look for the soil of ancient formation, on which he had already discovered a specimen of ore. They found the vein above ground, near the source of the creek, at the foot of one of the northeastern spurs. This ore, very rich in iron, enclosed in its fusible veinstone, was perfectly suited to the mode of reduction which the engineer intended to employ; that is, the Catalan method, but simplified, as it is used in Corsica. In fact, the Catalan method, properly so called, requires the construction of kilns and crucibles, in which the ore and the coal, placed in alternate layers, are transformed and reduced, But Cyrus Harding intended to economize these constructions, and wished simply to form, with the ore and the coal, a cubic mass, to the center of which he would direct the wind from his bellows. Doubtless, it was the proceeding employed by Tubalcain, and the first metallurgists of the inhabited world. Now that which had succeeded with the grandson of Adam, and which still yielded good results in countries rich in ore and fuel, could not but succeed with the settlers in Lincoln Island.
The coal, as well as the ore, was collected without trouble on the surface of the ground. They first broke the ore into little pieces, and cleansed them with the hand from the impurities which soiled their surface. Then coal and ore were arranged in heaps and in successive layers, as the charcoal-burner does with the wood which he wishes to carbonize. In this way, under the influence of the air projected by the blowing-machine, the coal would be transformed into carbonic acid, then into oxide of carbon, its use being to reduce the oxide of iron, that is to say, to rid it of the oxygen.
Thus the engineer proceeded. The bellows of sealskin, furnished at its extremity with a nozzle of clay, which had been previously fabricated in the pottery kiln, was established near the heap of ore. Using the mechanism which consisted of a frame, cords of fiber and counterpoise, he threw into the mass an abundance of air, which by raising the temperature also concurred with the chemical transformation to produce in time pure iron.
The operation was difficult. All the patience, all the ingenuity of the settlers was needed; but at last it succeeded, and the result was a lump of iron, reduced to a spongy state, which it was necessary to shingle and fagot, that is to say, to forge so as to expel from it the liquefied veinstone. These amateur smiths had, of course, no hammer; but they were in no worse a situation than the first metallurgist, and therefore did what, no doubt, he had to do.
A handle was fixed to the first lump, and was used as a hammer to forge the second on a granite anvil, and thus they obtained a coarse but useful metal. At length, after many trials and much fatigue, on the 25th of April several bars of iron were forged, and transformed into tools, crowbars, pincers, pickaxes, spades, etc., which Pencroft and Neb declared to be real jewels. But the metal was not yet in its most serviceable state, that is, of steel. Now steel is a combination of iron and coal, which is extracted, either from the liquid ore, by taking from it the excess of coal, or from the iron by adding to it the coal which was wanting. The first, obtained by the decarburation of the metal, gives natural or puddled steel; the second, produced by the carburation of the iron, gives steel of cementation.
It was the last which Cyrus Harding intended to forge, as he possessed iron in a pure state. He succeeded by heating the metal with powdered coal in a crucible which had previously been manufactured from clay suitable for the purpose.
He then worked this steel, which is malleable both when hot or cold, with the hammer. Neb and Pencroft, cleverly directed, made hatchets, which, heated red-hot, and plunged suddenly into cold water, acquired an excellent temper.
Other instruments, of course roughly fashioned, were also manufactured; blades for planes, axes, hatchets, pieces of steel to be transformed into saws, chisels; then iron for spades, pickaxes, hammers, nails, etc. At last, on the 5th of May, the metallic period ended, the smiths returned to the Chimneys, and new work would soon authorize them to take a fresh title.
Chapter 16
It was the 6th of May, a day which corresponds to the 6th of November in the countries of the Northern Hemisphere. The sky had been obscured for some days, and it was of importance to make preparations for the winter. However, the temperature was not as yet much lower, and a centigrade thermometer, transported to Lincoln Island, would still have marked an average of ten to twelve degrees above zero. This was not surprising, since Lincoln Island, probably situated between the thirty-fifth and fortieth parallel, would be subject, in the Southern Hemisphere, to the same climate as Sicily or Greece in the Northern Hemisphere. But as Greece and Sicily have severe cold, producing snow and ice, so doubtless would Lincoln Island in the severest part of the winter and it was advisable to provide against it.
In any case if cold did not yet threaten them, the rainy season would begin, and on this lonely island, exposed to all the fury of the elements, in mid-ocean, bad weather would be frequent, and probably terrible. The question of a more comfortable dwelling than the Chimneys must therefore be seriously considered and promptly resolved on.
Pencroft, naturally, had some predilection for the retreat which he had discovered, but he well understood that another must be found. The Chimneys had been already visited by the sea, under circumstances which are known, and it would not do to be exposed again to a similar accident.
“Besides,” added Cyrus Harding, who this day was talking of these things with his companions, “we have some precautions to take.”
“Why? The island is not inhabited,” said the reporter.
“That is probable,” replied the engineer, “although we have not yet explored the interior; but if no human beings are found, I fear that dangerous animals may abound. It is necessary to guard against a possible attack, so that we shall not be obliged to watch every night, or to keep up a fire. And then, my friends, we must foresee everything. We are here in a part of the Pacific often frequented by Malay pirates—”
“What!” said Herbert, “at such a distance from land?”
“Yes, my boy,” replied the engineer. “These pirates are bold sailors as well as formidable enemies, and we must take measures accordingly.”
“Well,” replied Pencroft, “we will fortify ourselves against savages with two legs as well as against savages with four. But, captain, will it not be best to explore every part of the island before undertaking anything else?”
“That would be best,” added Gideon Spilett.
“Who knows if we might not find on the opposite side one of the caverns which we have searched for in vain here?”
“That is true,” replied the engineer, “but you forget, my friends, that it will be necessary to establish ourselves in the neighborhood of a watercourse, and that, from the summit of Mount Franklin, we could not see towards the west, either stream or river. Here, on the contrary, we are placed between the Mercy and Lake Grant, an advantage which must not be neglected. And, besides, this side, looking towards the east, is not exposed as the other is to the trade-winds, which in this hemisphere blow from the northwest.”
“Then, captain,” replied the sailor, “let us build a house on the edge of the lake. Neither bricks nor tools are wanting now. After having been brickmakers, potters, smelters, and smiths, we shall surely know how to be masons!”
“Yes, my friend; but before coming to any decision we must consider the matter thoroughly. A natural dwelling would spare us much work, and would be a surer retreat, for it would be as well defended against enemies from the interior as those from outside.”
“That is true, Cyrus,” replied the reporter, “but we have already examined all that mass of granite, and there is not a hole, not a cranny!”
“No,